Bramhall · AdBlue & DPF
AdBlue & DPF repair in Bramhall
Bramhall drivers mostly bring us premium diesels with SCR and DPF faults — the kind of car where a main-dealer quote is eye-watering. We diagnose properly and repair for a fixed price instead.
AdBlue / SCR faults
NOx sensors, AdBlue pump and injector failures, crystallised dosing units and the countdown-to-non-start warning diagnosed and repaired properly. From £180.
Blocked DPF
Pressure-sensor checks, live soot readings, forced regeneration and on-vehicle cleaning so the filter works again instead of going straight back into limp mode.
EGR faults
Sticking valves, coolers and carbon build-up causing rough idle, smoke and limp mode — cleaned, repaired or replaced with the fault codes cleared.
Diesel diagnostics
Full live-data session before any work so you know exactly what has failed — no guesswork parts, and the diagnostic goes towards the repair.
Getting to us from Bramhall
Bramhall is around 25 minutes to our Salford M7 1UL workshop via the A34 and M60, and we cover Woodford, Poynton side and the villages along the A5102.
Most work is done at the workshop (Salford, M7 1UL) because we can road test and re-run the regeneration properly. If the vehicle genuinely can't be driven, tell us and we'll advise.
Vehicles we see most from Bramhall: BMW 520d and X5, Audi A6 and Q5 TDI, Mercedes C220d and E-Class, Range Rover Evoque and VW Tiguan.
Bramhall AdBlue & DPF questions
Is repairing the AdBlue system cheaper than the main dealer?
Almost always. We diagnose the exact failed component rather than replacing the whole SCR module, with a fixed £250 price and the diagnostic taken off the bill.
Will an AdBlue or DPF repair affect my car's warranty?
Genuine fault repair with correct parts doesn't invalidate cover on the rest of the car. We record what was tested and replaced so you have the paperwork.
My DPF light comes on during short trips around Bramhall — is that normal?
On a car doing school runs and short A34 hops, yes — the filter loads faster than it can burn off. We'll clean it and show you the soot figures so you know it's actually clear.
Can I leave the car with you for the day?
Yes. Drop it at the workshop in the morning and we'll message you with the diagnosis and a price before doing any work.
Read up before you book
Our fault guides explain what your warning light or countdown actually means.