Shaw · AdBlue & DPF
AdBlue & DPF repair in Shaw
Shaw drivers bring us vans and family diesels with AdBlue countdowns, DPF lights and EGR faults. We diagnose the real fault and repair it for a fixed price — honest advice before any work starts.
AdBlue / SCR faults
NOx sensors, AdBlue pump and injector failures, crystallised dosing units and the countdown-to-non-start warning diagnosed and repaired properly. From £180.
Blocked DPF
Pressure-sensor checks, live soot readings, forced regeneration and on-vehicle cleaning so the filter works again instead of going straight back into limp mode.
EGR faults
Sticking valves, coolers and carbon build-up causing rough idle, smoke and limp mode — cleaned, repaired or replaced with the fault codes cleared.
Diesel diagnostics
Full live-data session before any work so you know exactly what has failed — no guesswork parts, and the diagnostic goes towards the repair.
Getting to us from Shaw
Shaw is around 25 minutes to our Salford M7 1UL workshop via the A663 and M60, and we cover Crompton, High Crompton and Newhey side.
Most work is done at the workshop (Salford, M7 1UL) because we can road test and re-run the regeneration properly. If the vehicle genuinely can't be driven, tell us and we'll advise.
Vehicles we see most from Shaw: Ford Transit and Custom, Vauxhall Vivaro, Peugeot Expert, Citroën Dispatch, VW Transporter and family diesels like the Octavia and Focus.
Shaw AdBlue & DPF questions
My van shows an AdBlue countdown — can you fix it before it stops?
Yes. Bring it in before the countdown hits zero and we'll scan it, find the failed part and repair it for a fixed £250 in most cases. Don't leave it until it won't start.
Is repairing the AdBlue system cheaper than the main dealer?
Almost always. We diagnose the exact failed component rather than replacing the whole SCR module, with a fixed £250 price and the diagnostic taken off the bill.
My DPF light comes on during short trips around Shaw — is that normal?
On a car doing short runs, yes — the filter loads faster than it can burn off. We'll clean it and show you the soot figures so you know it's actually clear.
Do you come to me in Shaw?
For mobile DPF cleaning, yes — home or workplace. AdBlue and ECU repairs are workshop jobs, about 25 minutes away in Salford.
Read up before you book
Our fault guides explain what your warning light or countdown actually means.