Tyldesley · AdBlue & DPF
AdBlue & DPF repair in Tyldesley
Tyldesley drivers bring us vans and diesels with AdBlue warnings, NOx sensor faults and blocked DPFs. We diagnose the real fault and repair it for a fixed price — no dealer-sized bills.
AdBlue / SCR faults
NOx sensors, AdBlue pump and injector failures, crystallised dosing units and the countdown-to-non-start warning diagnosed and repaired properly. From £180.
Blocked DPF
Pressure-sensor checks, live soot readings, forced regeneration and on-vehicle cleaning so the filter works again instead of going straight back into limp mode.
EGR faults
Sticking valves, coolers and carbon build-up causing rough idle, smoke and limp mode — cleaned, repaired or replaced with the fault codes cleared.
Diesel diagnostics
Full live-data session before any work so you know exactly what has failed — no guesswork parts, and the diagnostic goes towards the repair.
Getting to us from Tyldesley
Tyldesley is around 15 minutes to our Salford M7 1UL workshop via the A580 East Lancs, and we cover Astley, Mosley Common and Boothstown for mobile work.
Most work is done at the workshop (Salford, M7 1UL) because we can road test and re-run the regeneration properly. If the vehicle genuinely can't be driven, tell us and we'll advise.
Vehicles we see most from Tyldesley: Ford Transit and Custom, Mercedes Sprinter, Vauxhall Vivaro, Peugeot Boxer, VW Crafter and family diesels doing the East Lancs commute.
Tyldesley AdBlue & DPF questions
My dashboard says 'AdBlue: starting impossible in 700 miles' — what do I do?
Book in before it counts down to zero. That's usually a pump, injector or NOx sensor fault — we scan it, tell you exactly what's failed and fix it for a fixed £250 in most cases.
Is repairing the AdBlue system cheaper than the main dealer?
Almost always. We diagnose the exact failed component rather than replacing the whole SCR module, with a fixed £250 price and the diagnostic taken off the bill.
My DPF light comes on during short trips around Tyldesley — is that normal?
On a car doing short runs, yes — the filter loads faster than it can burn off. We'll clean it and show you the soot figures so you know it's actually clear.
Can I leave the car with you for the day?
Yes. Drop it at the workshop in the morning and we'll message you with the diagnosis and a price before doing any work.
Read up before you book
Our fault guides explain what your warning light or countdown actually means.